Fog Storm™ Series
Introduction
Introduction: Congratulations, you have just purchased one of
the most reliable fog machines on the market today! The Fog Storm™
Series commercial fog machines have been designed to perform reli-
ably for years when the guidelines in this booklet are followed. Please
read and understand the instructions in this manual carefully and
thoroughly before attempting to operate this unit. These instructions
contain important information regarding safety during use and main-
tenance.
®
American DJ
Series
Customer Support: American DJ® provides a toll free customer
support line, to provide set up help and to answer any question should
you encounter problems during your set up or initial operation. You
ments or suggestions. For service related issue please contact Ameri-
can DJ®. Service Hours are Monday through Friday 9:00 a.m. to 5:00
p.m. Pacific Standard Time.
Voice:
Fax:
(800) 322-6337
(323) 582-2610
E-mail:
Warning! To prevent or reduce the risk of electrical shock or fire, do
not expose this unit to rain or moisture.
Caution! There are no user serviceable parts inside this unit. Do
not attempt any repairs yourself, doing so will void your manufactures
warranty. In the unlikely event your unit may require service please
contact American DJ®
.
Do not discard the shipping cartoon in the trash. Please recycle when
ever possible.
SAFETY ISSUES:
NEVER POINT OR AIM A FOG MACHINE TOWARDS PEOPLE OR
THEIR CLOTHING. THIS UNIT EMITS HOT VAPOR AND SHOULD
BE USED WITH THE SAME CARE THAT YOU WOULD OBSERVE
WHEN USING AN ELECTRIC KETTLE OR IRON.
User Instructions
American DJ
Please Note: Specifications and improvements in the design of
this unit and this manual are subject to change without any prior
written notice.
4295 Charter Street
Los Angeles Ca. 90058
Rev 12/03
©American DJ Supply® - Fog Storm™ Series - Instruction Manual Page 2
Fog Storm™ Series
Operating Instructions
Fog Storm™ Series
Clean Machine
Always be sure to maintain an adequate supply of American
DJ® Brand Fog Juice™ in the fluid reservoir. Running the fog
machine dry will cause pump failure and or clogging. This is the
largest cause of failure in fog and haze machines. Only American
Fog Juice™ is recommended and not all fog juice is created
equal.
To help prevent the unit from clogging, use American DJ® Clean
Machine™ liquid. Clean Machine is recommended when storing your
fogger for more than 1 week, or at least once a month as normal
maintenance under regular usage. Clean Machine removes particle
build up in the heater and gives longer life to the fog machine. Clean
Machine is like a tune up for your fog machine! Clean Machine is
available in gallon or quart bottles.
Remote Operation: The remote control comes connected to the
fog machine but can be removed to access the 25 foot cord. Once
the machine is plugged in and turned on, a red power L.E.D. on the
remote will glow indicating the unit is receiving power. The unit has
a warm up time of five (5) minutes. After the unit has warmed up, a
GREEN L.E.D. on the remote will light indicating the unit is ready to
emit fog. To emit fog, simply press the green button on the remote
for desired length of time. If the GREEN L.E.D. is on and fog does
not come out after holding the button down for 30 seconds, check
the fluid tank and hose to make sure there is fluid going through the
hose.
Fog Storm™ Series
Warranty Registration
The Fog Strom™ series fog machines carries a one year (365 days)
limited warranty. Please fill out the enclosed warranty card to validate
your purchase. All returned service items whether under warranty or
not, must be freight pre-paid and accompany a return authorization
(R.A.) number. The R.A. number must be clearly written on the out-
side of the return package. A brief description of the problem as well
as the R.A. number must also be written down on a piece of paper
and included in the shipping container. If the unit is under warranty,
you must provide a copy of your proof of purchase invoice. You may
obtain a R.A. number by contacting customer support at (800) 322-
6337.
Optional Timer: You can also operate the fog output automatically
by purchasing the optional timer remote. The timer function allows
haze to be emitted at designated intervals. The remote has three
(3) L.E.D.s that indicate different functions; The YELLOW L.E.D. will
indicate the timer is off and not activated. The RED L.E.D. indicates
power is on. The GREEN L.E.D. indicates fog output is available. The
remote also contains two rotary knobs. The Duration knob serves
two functions 1) Turns the timer on and off. 2) Sets the timers dura-
tion (Length of fog output). The interval knob sets the amount of time
in between fog output from 30 seconds to 10 minutes. Turing these
knobs in a clockwise direction will increase there values, turning
them in a counter-clockwise direction will decrease their values.
Fog Storm™ Series
Trouble Shooting
If you experience low fog output, pump noise, or no fog output at all,
disconnect and discontinue use immediately. Do not attempt to con-
tinue pushing the remote control’s activation button as this may dam-
age the fog machine. Check fluid level, the external fuse or breaker,
remote connection, and be sure the wall outlet is sending power. If
all of the above appear to be okay, and the unit fails to operate cor-
rectly, the unit will require service. Return the machine to an American
DJ® authorized dealer or service center.
Caution: Before removing or replacing the remote control unit
disconnect the power supply.
©American DJ Supply® - Fog Storm™ Series Instruction Manual Page 5
©American DJ Supply® - Fog Storm™ Series Instruction Manual Page 6
Fog Storm™ Series
Warranty
Fog Storm™ Series
Specifications
1 YEAR LIMITED WARRANTY
MODEL - Fog Storm 700™
VOLTAGE*:
120v~50/60Hz or 230v~50Hz
8 Lbs. / 3.5 Kgs
9.5" x 6” x 5.25” / 240 x 150 x 130 mm
120v=10A/30mm or 230v=5A/30mm
5 Minutes
A. American DJ® hereby warrants, to the original purchaser, American DJ® products to be
free of manufacturing defects in material and workmanship for a period of one year (365
days) from the date of purchase. This warranty shall be valid only if the product is purchased
within the United States of America, including possessions and territories. It is the ownerʼs
responsibility to establish the date and place of purchase by acceptable evidence, at the
time service is sought.
WEIGHT:
DIMENSIONS:
FUSE:
WARM UP TIME:
TANK CAPACITY:
OUTPUT:
FLUID TYPE:
DUTY CYCLE:
HEATER:
1 Liter Removable
3500 cubic feet per minute
Water Base American DJ Fog Juice™
Not to exceed 6 hours turned on.
700 watt
B. For warranty service, send the product only to the American DJ® factory. All shipping
charges must be pre-paid. If the requested repairs or service (including parts replacement)
are within the terms of this warranty, American DJ® will pay return shipping charges only to a
designated point within the United States. If the entire instrument is sent, it must be shipped
in its original package. No accessories should be shipped with the product. If any acces-
sories are shipped with the product, American DJ® shall have no liability whatsoever for loss
of or damage to any such accessories, nor for the safe return thereof.
*Voltage is preset at the factory and may not be changed
MODEL - Fog Storm 1200™
VOLTAGE*:
120v~50/60Hz or 230v~50Hz
12 Lbs. / 5.4 Kgs
12" x 8.75 x 6.5” / 300 x 220 x 160 mm
120v=12A/30mm or 230v=7A/30mm
8 Minutes
C. This warranty is void if the serial number has been altered or removed; if the product
is modified in any manner which American DJ® concludes, after inspection, affects the reli-
ability of the product; if the product has been repaired or serviced by anyone other than
the American DJ® factory unless prior written authorization was issued to purchaser by
American DJ®; if the product is damaged because not properly maintained as set forth in the
instruction manual.
WEIGHT:
DIMENSIONS:
FUSE:
WARM UP TIME:
TANK CAPACITY:
OUTPUT:
FLUID TYPE:
DUTY CYCLE:
HEATER:
2.5 Liter Removable
7000 cubic feet per minute
Water Base American DJ Fog Juice™
Not to exceed 6 hours turned on.
1200 watt
D. This is not a service contract, and this warranty does not include maintenance, cleaning
or periodic check-up. During the period specified above, American DJ® will replace defective
parts at its expense, and will absorb all expenses for warranty service and repair labor by
reason of defects in material or workmanship. The sole responsibility of American DJ® under
this warranty shall be limited to the repair of the product, or replacement thereof, including
parts, at the sole discretion of American DJ®. All products covered by this warranty were
manufactured after January 1, 1990, and bear identifying marks to that effect.
*Voltage is preset at the factory and may not be changed
MODEL - Fog Storm 1700™
VOLTAGE*:
WEIGHT:
DIMENSIONS:
BREAKER:
WARM UP TIME:
TANK CAPACITY:
OUTPUT:
FLUID TYPE:
DUTY CYCLE:
120v~50/60Hz or 230v~50Hz
22 Lbs. / 10 Kgs
17.25" x 11” x 11.5”/435 x 280 x 290 mm
120v = 20A NFB / 230v = 10A NFB
7 Minutes
E. American DJ® reserves the right to make changes in design and/or improvements upon
its products without any obligation to include these changes in any products theretofore
manufactured.
F. No warranty, whether expressed or implied, is given or made with respect to any acces-
sory supplied with products described above. Except to the extent prohibited by applicable
law, all implied warranties made by American DJ® in connection with this product, including
warranties of merchantability or fitness, are limited in duration to the warranty period set forth
above. And no warranties, whether expressed or implied, including warranties of merchant-
ability or fitness, shall apply to this product after said period has expired. The consumerʼs
and or Dealerʼs sole remedy shall be such repair or replacement as is expressly provided
above; and under no circumstances shall American DJ® be liable for any loss or damage,
direct or consequential, arising out of the use of, or inability to use, this product.
5 Liter Removable
15000 cubic feet per minute
Water Base American DJ Fog Juice™
Not to exceed 6 hours turned on.
1700 watt
HEATER:
*Voltage is preset at the factory and may not be changed
G. This warranty is the only written warranty applicable to American DJ® Products and
supersedes all prior warranties and written descriptions of warranty terms and conditions
heretofore published.
©American DJ Supply®
A Division of the American DJ Group of Companies
American DJ World Headquarters:
4295 Charter Street Los Angeles, CA 90058 USA
Tel: 323-582-2650 / Fax: 323-582-2610
H. Lamps are not covered under this warranty.
©American DJ Supply® - Fog Storm™ Series - Instruction Manual Page 7
|